振动条件下电磁继电器性能参数变化规律的研究

骆燕燕; 张兆攀; 张敏敏; 李鹏飞

doi:10.13890/j.issn.1000-128x.2020.04.023

您当前的位置：

首页 >

文章列表页 >

振动条件下电磁继电器性能参数变化规律的研究

研究开发 | 更新时间：2021-12-10

- 振动条件下电磁继电器性能参数变化规律的研究
- Research on the Change Law of Performance Parameters of Electromagnetic Relay under Vibration Condition
- 机车电传动 2020年第4期页码：113-117
- 作者机构：
  
  1.河北工业大学　省部共建电工装备可靠性与智能化国家重点实验室，天津　300130
  2.河北工业大学　河北省电磁场与电器可靠性重点实验室，天津　300130
  3.国网山东省电力公司检修公司，山东　济南　250000
  4.国网山西省电力公司检修公司，山西　太原　030000
- 作者简介：
  
  骆燕燕（1971—），女，博士，教授，博士生导师，主要研究方向为电器可靠性。
- 基金信息：
  
  河北省电工产品可靠性技术2011协同创新中心资助项目
- DOI：10.13890/j.issn.1000-128x.2020.04.023
  中图分类号：
扫描看全文
骆燕燕, 张兆攀, 张敏敏, 等. 振动条件下电磁继电器性能参数变化规律的研究[J]. 机车电传动, 2020,(4):113-117.

Yanyan LUO, Zhaopan ZHANG, Minmin ZHANG, et al. Research on the Change Law of Performance Parameters of Electromagnetic Relay under Vibration Condition[J]. Electric Drive for Locomotives, 2020,(4):113-117.
骆燕燕, 张兆攀, 张敏敏, 等. 振动条件下电磁继电器性能参数变化规律的研究[J]. 机车电传动, 2020,(4):113-117. DOI： 10.13890/j.issn.1000-128x.2020.04.023.

Yanyan LUO, Zhaopan ZHANG, Minmin ZHANG, et al. Research on the Change Law of Performance Parameters of Electromagnetic Relay under Vibration Condition[J]. Electric Drive for Locomotives, 2020,(4):113-117. DOI： 10.13890/j.issn.1000-128x.2020.04.023.

摘要

长期的振动往往会引起电磁继电器的性能降低，甚至失效。针对电磁继电器的工作环境特点，提出了一种电磁继电器振动试验方案，设计了试验电路并进行了试验。试验结果表明：振动频率为40~130 Hz和振动加速度增大时，电磁继电器的释放时间与回跳时间无明显变化、吸合电压减小、释放电压和接触电阻缓慢增加、吸合时间的增幅及其波动量最为明显；在固有频率160 Hz下，性能参数均出现了明显的变化和剧烈的波动，最大波动量约为其他振动条件下的2倍；与振动频率相比，振动加速度对性能参数的影响更大些。通过数据分析发现，振动引发的电磁继电器性能参数变化中，吸合时间是较为敏感的参数。

Abstract

Long-term vibrations often cause performance degradation or even failure of electromagnetic relays. In view of the working environment characteristics of electromagnetic relays, a vibration test scheme for electromagnetic relay was proposed. The test circuit was designed and tested. The test results showed that, when the vibration frequency is 40-130 Hz, and when the vibration acceleration increases, the release time and the bouncing time do not change signi fi cantly, the pull-in voltage decreases, the release voltage and contact resistance increase slowly, and the increase of the pick-up time and the fluctuation is the most obvious; Under the natural frequency 160 Hz, the performance parameters are obviously changed with the violent fluctuations, and the maximum fluctuation is about 2 times of other vibration conditions; Compared with the vibration frequency, the vibration acceleration has greater effect on the performance parameters. It was found that in the change of performance parameters of electromagnetic relay caused by vibration, the suction time is a more sensitive parameter.

关键词

电磁继电器振动性能参数参数检测

Keywords

electromagnetic relayvibrationperformance parameterparameter test

references

WANG G T, WANG S J, LI K. A study on the activation condition of vibration tests for particle impact noise detection of space relay remainders[C]//IEEE. 2011 6th IEEE Conference on Industrial Electronics and Applications. Beijing: IEEE, 2011: 2610-2614. DOI: 10.1109/ICIEA.2011.5976034http://doi.org/10.1109/ICIEA.2011.5976034.

李玲玲, 张士暖, 李志刚, 等. 基于粗糙集理论和生命初态信息的继电器寿命预测方法[J]. 电工技术学报, 2016, 31(18): 46-53.

WANG J, YAO F, LI Z G. Study on acquiring key performance parameters and comprehensive performance degradation model of relays[C]//IEEE. 26th International Conference on Electrical Contacts. Beijing: IEEE, 2012: 306-310. DOI: 10.1049/cp.2012.0666http://doi.org/10.1049/cp.2012.0666.

REN W B, LIANG H M, CHEN Y H, et al. Mechanical and electrical characteristics of the electromagnetic relay under vibration and shock environment[C]//IEEE. 2009 Proceedings of the 55th IEEE Holm Conference on Electrical Contacts. Vancouver: IEEE,2009: 42-48. DOI: 10.1109/HOLM.2009.5284425http://doi.org/10.1109/HOLM.2009.5284425.

MIYANAGA K, MATSUMOTO S, TAKAHASHI K, et al. A study on growth of dust of needle-like crystal from a flame retarder of electromagnetic relay housing[C]//IEEE. 2018 IEEE Holm Conference on Electrical Contacts. Albuquerque: IEEE, 2018: 516-520. DOI: 10.1109/HOLM.2018.8611773http://doi.org/10.1109/HOLM.2018.8611773.

肖斌, 杨文英, 谢林炜, 等. 电磁继电器额定寿命优化设计[J]. 哈尔滨工业大学学报, 2019, 51(3): 29-36.

ZHAI G F, CHEN Y H, REN W B. Analyzing method of random vibration characteristic for armature system of hermetically sealed electromagnetic relay[C]//IEEE. Electrical Contacts - 2007 Proceedings of the 53rd IEEE Holm Conference on Electrical Contacts. Pittsburgh: IEEE, 2007: 183-187. DOI: 10.1109/HOLM.2007.4318214http://doi.org/10.1109/HOLM.2007.4318214.

LAMBRECHT N, PUES H, DE ZUTTER D, et al. Modeling of contact bounce in a transient electromagnetic compatibility test for the analysis and optimization of nonlinear devices[J]. IEEE Transactions on Electromagnetic Compatibility, 2017, 59(2): 541-544.

赵韩, 于海丹, 杨旭, 等. 交流负载下拍合式功率继电器触点释放回跳现象优化技术研究[J]. 电器与能效管理技术, 2014 (22): 10-15.

焦玉斌, 郑浩野, 任万滨, 等. 振动环境对电磁继电器特性参数影响的试验研究[J]. 低压电器, 2011 (3): 8-11.

叶雪荣, 林义刚, 黄晓毅, 等. 航天继电器贮存过程吸合时间退化机理研究[J]. 电工技术学报, 2017, 32(11): 173-179.

罗依金. 小型密封电磁继电器[M]. 王蓉芳，译. 北京: 人民邮电出版社, 1979.

浏览量

下载量

CSCD

CNKI被引量

文章被引用时，请邮件提醒。

提交

工具集

关联资源

弹性车轮迟缓机理研究与解决方案探讨

小半径曲线对地铁车辆客室噪声偏高的影响分析

基于实际线路工况的地铁车辆牵引电机振动数值分析研究

高寒动车组牵引变流器运行环境特性研究

车下设备激励对车体模态匹配的影响