车轮多边形对米轨机车动力学性能影响的研究

胡静涛; 杨九河; 丁军君; 李朝曦; 李芾

doi:10.13890/j.issn.1000-128x.2019.02.009

您当前的位置：

首页 >

文章列表页 >

车轮多边形对米轨机车动力学性能影响的研究

研究开发 | 更新时间：2021-12-13

- 车轮多边形对米轨机车动力学性能影响的研究
- Influence of Polygon Wheel on Dynamic Performance of Meter-gauge Locomotive
- 机车电传动 2019年第2期页码：44-48
- 作者机构：
  
  1.西南交通大学　机械工程学院，四川　成都　610031
  2.中国铁路成都局集团有限公司，四川　成都　610082
- 作者简介：
  
  胡静涛（1993—），男，硕士研究生，研究方向为机车车辆系统动力学。
- 基金信息：
  
  中央高校基本科研业务费专项资金资助项目(2682016CX029);四川省青年科技创新研究团队项目(2017TD0017)
- DOI：10.13890/j.issn.1000-128x.2019.02.009
  中图分类号：
扫描看全文
胡静涛, 杨九河, 丁军君, 等. 车轮多边形对米轨机车动力学性能影响的研究[J]. 机车电传动, 2019,(2):44-48.

Jingtao HU, Jiuhe YANG, Junjun DING, et al. Influence of Polygon Wheel on Dynamic Performance of Meter-gauge Locomotive[J]. Electric Drive for Locomotives, 2019,(2):44-48.
胡静涛, 杨九河, 丁军君, 等. 车轮多边形对米轨机车动力学性能影响的研究[J]. 机车电传动, 2019,(2):44-48. DOI： 10.13890/j.issn.1000-128x.2019.02.009.

Jingtao HU, Jiuhe YANG, Junjun DING, et al. Influence of Polygon Wheel on Dynamic Performance of Meter-gauge Locomotive[J]. Electric Drive for Locomotives, 2019,(2):44-48. DOI： 10.13890/j.issn.1000-128x.2019.02.009.

摘要

为研究米轨机车车轮多边形化对机车系统动力学性能的影响，建立米轨机车动力学模型，研究车轮多边形的谐波阶数和波深幅值对动力学性能的影响，并计算不同谐波阶数下车轮多边形的波深限值，最后对车轮多边形和轨道激励共同作用下轮轨垂向力的变化趋势进行分析。结果表明：由于米轨机车运行速度较低，车轮多边形化会导致低频振动，使得车体振动响应增大；车轮多边形化会极大地增加轮轨垂向力，但对脱轨系数影响不大；波深限值与机车运行速度及车轮多边形谐波阶数成反比；轨道激励不仅不会掩盖多边形的作用趋势，而且会极大地增加轮轨垂向力。机车在线路上运行时应经常检测车轮不圆度，并及时镟修或者更换车轮，防止出现轮轨垂向力过大或跳轨现象。

Abstract

In order to study the influence of the polygon wheel of meter-gauge locomotive on the dynamic performance of the vehicle system, a dynamic model of meter-gauge locomotive was established. The influence of harmonic order and the amplitude of the wave depth of the polygon wheel on the dynamic performance were calculated. The wave depth limit of the locomotive was studied at different harmonic order. At last, the change trend of wheel-rail vertical forces was studied under the joint action of polygon wheel and track excitation. The results showed that due to the low running speed of the meter-gauge locomotive, the polygon wheel will form low frequency vibration which will increase the vibration response of the car body; the polygon wheel will greatly increase the wheel-rail vertical forces, but it has little effect on the derailment coefficient; the wave depth limit is inversely proportional to the running speed of the locomotive and the harmonic order; the track excitation will not cover the trend caused by polygon wheel, but it will greatly increase the wheel-rail vertical forces. Therefore, it’s necessary to detect the wheel out of roundness frequently when the locomotive is running on rail, and lathing or replacing wheel in time in order to prevent the wheel-rail vertical forces is too large or the jumping of wheels.

关键词

车轮多边形米轨机车动力学性能谐波阶数波深

Keywords

polygon wheelmeter-gauge locomotivedynamic performanceharmonic orderwave depth

references

KALOUSEK J, JOHNSON K L. An investigation of short pitch wheel and rail corrugations on the Vancouver mass transit system[J]. Proceedings of the Institution of Mechanical Engineers, Part F: Journal of Rail & Rapid Transit, 1992, 206(26): 127-135.

JOHANSSON A, NIELSEN J C O. Out-of-round railway wheels wheel rail contact forces and track response derived from field tests and numerical simulations[J]. Proceedings of the Institution of Mechanical Engineers, Part F: Journal of Rail & Rapid Transit, 2003, 217(2): 135-146.

POPP K, KAISER I, KRUSE H. System dynamics of railway vehicles and track[J]. Archive of Applied Mechanics, 2003, 72(11/12): 949-961.

MAZILU T, DUMITRIU M, TUDORACHE C, et al. Wheel/rail interaction due to the polygonal wheel[J]. UPB Scientific Bulletin Series D: Mechnical Engineering, 2011, 73(3): 94-108.

DEKKER H. Vibrational resonances of nonrigid vehicles: Polygonization and ripple patterns[J]. Applied Mathematical Modelling, 2009, 33(3): 1349-1355.

方翁武, 刘韦, 罗世辉, 等. 轮对多边形化对车辆动力学性能的影响[J]. 机车电传动, 2013 (4): 59-62.

袁雨青, 李强, 杨光. 横向振动对列车车轮多边形磨耗的影响[J]. 北京交通大学学报, 2016, 40(1): 80-85.

孙伟. 车轮不圆对轴箱转臂疲劳强度的影响[D]. 成都: 西南交通大学, 2016.

刘佳, 韩健, 肖新标, 等. 高速车轮非圆化磨耗对轴箱端盖异常振动影响初探[J]. 机械工程学报, 2017, 53(20): 98-105.

陈光雄, 金学松, 邬平波, 等. 车轮多边形磨耗机理的有限元研究[J]. 铁道学报, 2011, 33(1): 14-18.

柳炜, 颜宁, 蒲全卫, 等. HXD1型机车轮对多边形发展趋势探讨[J]. 电力机车与城轨车辆, 2017, 40(6): 55-59.

凌世清, 陈后友. 外径测量仪对车轮径向跳动超差的适用性探讨[J]. 电力机车与城轨车辆, 2016, 39(2): 72-75.

陈伟. 高速列车车轮多边形问题研究[D]. 成都: 西南交通大学, 2014.

刘韦, 马卫华, 罗世辉, 等. 考虑轮对弹性的车轮振动及车轮多边形化对轮轨力影响研究[J]. 铁道学报, 2013, 35(6): 28-34.

浏览量

下载量

CSCD

CNKI被引量

文章被引用时，请邮件提醒。

提交

工具集

关联资源

轮对多边形化对车辆动力学性能的影响

速度160 km/h轨道车辆直向道岔通过性能研究

车轮多边形演变及其对车辆动力学影响

单车型低地板有轨电车旋转止挡布置方式研究

空气弹簧主动控制的摆式列车动力学性能研究