Vibration Testing and Resonance Fatigue Assessment of Axlebox Lifting Lug

Qingwei SONG; Dafu ZHANG; Jianbin WANG; Pingbo WU

doi:10.13890/j.issn.1000-128x.2019.05.112

您当前的位置：

首页 >

文章列表页 >

Vibration Testing and Resonance Fatigue Assessment of Axlebox Lifting Lug

Test & Detection | 更新时间：2021-12-13

- Vibration Testing and Resonance Fatigue Assessment of Axlebox Lifting Lug
- Electric Drive for Locomotives Issue 6, Pages: 134-139(2019)
- 作者机构：
  
  1.中车长春轨道客车股份有限公司　国家轨道客车系统集成工程技术研究中心，吉林　长春　130062
  2.西南交通大学　牵引动力国家重点实验室，四川　成都　610031
- 作者简介：
- 基金信息：
- DOI：10.13890/j.issn.1000-128x.2019.05.112
  CLC：
扫描看全文
Qingwei SONG, Dafu ZHANG, Jianbin WANG, et al. Vibration Testing and Resonance Fatigue Assessment of Axlebox Lifting Lug. [J]. Electric Drive for Locomotives (6):134-139(2019)
DOI：

Qingwei SONG, Dafu ZHANG, Jianbin WANG, et al. Vibration Testing and Resonance Fatigue Assessment of Axlebox Lifting Lug. [J]. Electric Drive for Locomotives (6):134-139(2019) DOI： 10.13890/j.issn.1000-128x.2019.05.112.

摘要

某线路地铁车辆轴箱吊耳发生多起断裂事故，因此针对该吊耳进行了振动测试、模态结构优化和共振疲劳计算。测试表明吊耳断裂为线路波磨频率与吊耳一阶固有模态频率发生共振所致，并通过仿真分析进行了吊耳模型验证和结构优化。以实测波磨路段动应力为输入，利用窄带疲劳寿命评估方法和Dirlik疲劳寿命评估方法对吊耳寿命进行评估，评估结果与实际基本一致，表明利用窄带法进行共振疲劳寿命评估基本可行；对于共振疲劳，当主频绝对单一时，Dirlik法计算结果与窄带法计算结果一致。

Abstract

The axlebox lifting lug of a metro vehicle had broken several times, so that vibration test, modal structure optimization and resonance fatigue assessment were carried out for the lifting lug. The test results showed that the reason of lifting lug breakage was the resonance between the corrugation frequency and the first natural mode frequency of the lifting lug. The lifting lug model was verified and the structure was optimized by simulation analysis. Based on the data which was measured on corrugation line, the lifting lug’s fatigue life was evaluated by the method of narrow-band fatigue life assessment and Dirlik fatigue life assessment method, and the assessment result was consistent with actual situation. It showed that the narrow-band method was basically feasible to evaluate the resonant fatigue life. For resonance fatigue, when the dominant frequency was absolutely single, the results of Dirlik method was agree with narrow band method.

关键词

轴箱吊耳振动测试模态结构优化共振疲劳寿命评估地铁车辆仿真

Keywords

axlebox lifting lugvibration testmodal structure optimizationresonance fatigue life assessmentmetro vehiclesimulation

references

焦群英, 王书茂, 才力, 等. 用于结构共振疲劳寿命估计的应变模态分析[J]. 机械工程学报, 1996, 32(6): 52-57.

刘文光, 陈国平, 贺红林, 等. 结构振动疲劳研究综述[J]. 工程设计学报, 2012, 19(1): 1-8.

薛鸿详, 唐文勇, 张圣坤. 深海立管涡激共振疲劳寿命简化计算方法[J]. 工程力学, 2008, 25(5): 231-234.

DOWNING S D, SOCIE D F. Simple rainflow counting algorithms[J]. International Journal of Fatigue, 1982, 4(1): 31-40.

ANTHES R J. Modified rainflow counting keeping the load sequence[J]. International Journal of Fatigue, 1997, 19(7): 529-535.

REPETTO M P. Cycle counting methods for bi-modal stationary Gaussian processes[J]. Probabilistic Engineering Mechanics, 2005, 20(3): 229-238.

GRIGORIU M. A spectral representation based modal for Monte Carlo simulation[J]. Probabilistic Engineering Mechanics, 2000, 15(4): 365-370.

侯传亮, 张永林. 工程平稳随机过程的数值模拟研究[J]. 武汉工业学院学报, 2003, 22(3): 27-29.

刘献栋, 邓志党, 高峰. 基于逆变换的路面不平度仿真研究[J]. 中国公路学报, 2005, 18(1): 122-126.

陈春俊, 李华超. 频域采样三角级数法模拟轨道不平顺信号[J]. 铁道学报, 2006, 28(3): 38-42.

刘寅华, 李芾, 黄运华. 轨道不平顺数值模拟方法[J]. 交通运输工程学报, 2006, 6(1): 29-33.

TOVO R. Cycle distribution and fatigue damage under broad-band random loading[J]. International Journal of Fatigue, 2002, 24(11): 1137-1147.

BENASCIUTTI D, TOVO R. Spectral method for lifetime prediction under wide-band stationary random processes[J]. International Journal of Fatigue, 2005, 27(8): 867-877.

吕澎民. 宽带随机载荷谱下结构疲劳寿命估算[J]. 长安大学学报(自然科学版), 2004, 24(1): 76-78.

KWOFIE S. An exponential stress functions for predicting fatigue strength and life due to mean stresses[J]. International Journal of Fatigue, 2001, 23(9): 829-836.

冯振宇, 诸德培, 林富甲. 随机载荷下的疲劳寿命估算[J]. 机械科学与技术, 1996, 15(6): 879-882.

BENDAT J S, PIERSOL A G. Measurement and analysis of random data[M]. New York: John Wiley & Sons, Inc., 1966.

DIRLIK T. Application of computers in fatigue analysis[D]. West Midlands: University of Warwick, 1985.

王明珠. 结构振动疲劳寿命分析方法研究[D]. 南京: 南京航空航天大学, 2009.

高淑英, 沈火明. 振动力学[M]. 2版.北京: 中国铁道出版社, 2011.

HOBBACHER A F. Recommendations for Fatigue Design of Welded Joints and Components[M]. Berlin: Springer International Publishing, 2016.

Views

下载量

CSCD

CNKI被引量

Alert me when the article has been cited

提交

Tools

Publicity Resources

Research on influencing factors to key parameters of hybrid DC circuit breaker and prototype development

Influence of Suspension Parameters on the Curve Passage Performance of Metro Vehicle under Crosswind in Mountain City

Thermal Analysis of Permanent Magnet Direct Drive Synchronous Traction Motor for Metro Vehicles

Design and Shielding Effect Test of Antimagnetic Plate Based on Air-cored Reactor for Metro Vehicles

New Method of Dynamics Performance Simulation for Metro Vehicle with Linear Motor

Related Author

No data

Related Institution

CRRC Zhuzhou Institute Co., Ltd.

School of Transportation Engineering, Jiangsu Shipping College

CRRC Zhuzhou Electric Co., Ltd.

CRRC Qingdao Sifang Co., Ltd.

School of Electrical Engineering, Beijing Jiaotong University

⁰