Low-order harmonic analysis and suppression strategy optimization of cascaded converters for train traction

LI Xiangchao; FENG Jiying; LI Zhenghui

doi:10.13890/j.issn.1000-128X.2024.02.011

您当前的位置：

首页 >

文章列表页 >

Low-order harmonic analysis and suppression strategy optimization of cascaded converters for train traction

Converting and Control | 更新时间：2024-08-02

- Low-order harmonic analysis and suppression strategy optimization of cascaded converters for train traction
- Electric Drive for Locomotives Issue 2, Pages: 92-100(2024)
- 作者机构：
  
  1.河南省轨道交通智能安全工程技术研究中心，河南郑州 451460
  2.郑州铁路职业技术学院，河南郑州 451460
  3.河南机电职业学院，河南郑州 450052
- 作者简介：
- 基金信息：
- DOI：10.13890/j.issn.1000-128X.2024.02.011
  CLC： TM461
- Published：10 March 2024，
  
  Received：12 October 2023，
  
  Revised：02 February 2024，
- 稿件说明：
扫描看全文
李向超, 冯继营, 李正辉. 牵引级联变流器低次谐波分析与抑制策略优化[J]. 机车电传动, 2024(2): 92-100.

LI Xiangchao, FENG Jiying, LI Zhenghui. Low-order harmonic analysis and suppression strategy optimization of cascaded converters for train traction[J]. Electric drive for locomotives,2024(2): 92-100.
李向超, 冯继营, 李正辉. 牵引级联变流器低次谐波分析与抑制策略优化[J]. 机车电传动, 2024(2): 92-100. DOI：10.13890/j.issn.1000-128X.2024.02.011.

LI Xiangchao, FENG Jiying, LI Zhenghui. Low-order harmonic analysis and suppression strategy optimization of cascaded converters for train traction[J]. Electric drive for locomotives,2024(2): 92-100. DOI：10.13890/j.issn.1000-128X.2024.02.011.

摘要

以级联H桥变流器为前级拓扑的电力电子变压器是未来列车牵引的重要发展方向，降低牵引级联变流器的低次谐波对提高电力电子变压器的控制性能具有重要意义。然而，引起级联H桥变流器低次谐波的影响因素与常规四象限变流器存在差异，其机理分析和抑制策略尚未得到深入研究。对此，文章详细探究了电力牵引网侧级联H桥变流器低次电流谐波产生机理，揭示了除直流电压波动、器件死区和管压降外，其低次谐波还与H桥级联的模块数及拓扑结构有关。在此基础上，设计一种兼顾直流电压波动和电路拓扑特性的低次谐波抑制算法。同时，结合功率器件的死区效应与管压降影响，提出级联H桥变流器低次电流谐波综合抑制策略。最后，搭建小功率试验平台进行测试，试验结果验证了理论分析的正确性和优化抑制方案的有效性。

Abstract

Power electronic transformers (PET) incorporating cascaded H-bridge (CHB) converters as the front-stage topology represent an important development trend for future train traction. Minimizing low-order harmonics in CHB converters holds immense importance in enhancing the control performance of PETs. However

the factors affecting low-order harmonics in CHB converters differ from those in conventional four-quadrant converters. There is still a lack of detailed research on the underlying mechanisms and suppression strategies. This paper delved into the generation mechanisms of low-order harmonics in CHB converters on the traction network side

highlighting that low-order harmonics were related to the module count and topology of H-bridge cascades

in addition to DC voltage fluctuations

device dead-zones and switching voltage drops. According to the findings

a low-order harmonic suppression algorithm was designed

taking into account DC voltage fluctuations and circuit topology characteristics. Furthermore

a comprehensive optimization strategy for suppressing low-order current harmonics in CHB converters was suggested

integrating the dead zone effects and voltage drop impacts. In the final section

an experiment using a low-power experimental platform was detailed. The experimental results verify the accuracy of the theoretical analysis and the effectiveness of the optimized suppression solution.

关键词

牵引级联H桥变流器低次谐波分析谐波抑制策略直流电压波动器件死区开关管压降

Keywords

cascaded H-bridge (CHB) of traction converterlow-order harmonic analysisharmonic suppression strategyDC voltage fluctuationdevice dead-zoneswitching voltage drop

references

国家铁路局. “十四五”铁路科技创新规划[R/OL]. (2021-12-23) [2023-12-16]. https://www.nra.gov.cn/xwzx/xwxx/xwlb/202204/t20220405_280556.shtmlhttps://www.nra.gov.cn/xwzx/xwxx/xwlb/202204/t20220405_280556.shtml.

National Railway Administration. The 14th five-year plan for railway science and technology innovation[R/OL]. (2021-12-23) [2023-12-16]. https://www.nra.gov.cn/xwzx/xwxx/xwlb/202204/t20220405_280556.shtmlhttps://www.nra.gov.cn/xwzx/xwxx/xwlb/202204/t20220405_280556.shtml.

陈涛, 苏亮亮, 张志学, 等. 牵引电力电子变压器系统关键技术研究[J]. 机车电传动, 2022(3): 130-137.

CHEN Tao, SU Liangliang, ZHANG Zhixue, et al. Research on key technologies for power electronic traction transformer[J]. Electric drive for locomotives, 2022(3): 130-137.

薄天赐, 马磊, 陈妍, 等. 单相CHBR改进型无网压传感器直接功率控制[J]. 电机与控制学报, 2023, 27(9): 31-41.

BO Tianci, MA Lei, CHEN Yan, et al. Improved grid voltage sensorless direct power control for single-phase CHBR[J]. Electric machines and control, 2023, 27(9): 31-41.

窦泽春. PETT高压级联整流器控制策略研究[J]. 机车电传动, 2022(4): 37-44.

DOU Zechun. Research on control strategy of high-voltage cascade rectifier in PETT[J]. Electric drive for locomotives, 2022(4): 37-44.

吴连贵, 涂春鸣, 姜飞, 等. 级联H桥型逆变器载波移相正弦脉宽调制输出性能分析[J]. 电网技术, 2016, 40(7): 2155-2161.

WU Liangui, TU Chunming, JIANG Fei, et al. Characteristic analysis of carrier phase-shifted SPWM output voltage of cascaded H-bridge converters[J]. Power system technology, 2016, 40(7): 2155-2161.

LIN Hongjian, LIN Chunxu, XIE Dong, et al. A counter-based open-circuit switch fault diagnostic method for a single-phase cascaded H-bridge multilevel converter[J]. IEEE transactions on power electronics, 2024, 39(1): 814-825.

王付胜, 戴之强, 王佳宁, 等. 一种基于级联H桥光伏并网逆变器的变移相角载波移相调制策略[J]. 太阳能学报, 2020, 41(8): 144-150.

WANG Fusheng, DAI Zhiqiang, WANG Jianing, et al. A variable-angle phase-shifted PWM strategy for cascaded H-bridge photovoltaic grid-connected inverter[J]. Acta energiae solaris sinica, 2020, 41(8): 144-150.

赵卫, 刘文生. 牵引变流器网侧电流低次谐波抑制的研究[J]. 机车电传动, 2017(3): 24-29.

ZHAO Wei, LIU Wensheng. Research on suppression of net-side low-order harmonics current in the traction converter[J]. Electric drive for locomotives, 2017(3): 24-29.

陶海军, 张晨杰, 赵蒙恩, 等. 级联H桥整流器谐波分析及混合控制[J]. 电力系统保护与控制, 2023, 51(22): 24-33.

TAO Haijun, ZHANG Chenjie, ZHAO Mengen, et al. Harmonic analysis and hybrid control of a cascaded H-bridge rectifier[J]. Power system protection and control, 2023, 51(22): 24-33.

李鹏, 邹志超. 动力集中动车组电气系统关键技术分析与验证[J]. 机车电传动, 2024(1): 109-121.

LI Peng, ZOU Zhichao. Analysis and verification of key technologies for electrical systems of power concentrated EMUs[J]. Electric drive for locomotives, 2024(1): 109-121.

张文明, 葛兴来, 冯晓云. 单相三电平PWM整流器网侧谐波分析[J]. 电力电子技术, 2014, 48(9): 62-64.

ZHANG Wenming, GE Xinglai, FENG Xiaoyun. Harmonic analysis of the single-phase three-level PWM rectifier[J]. Power electronics, 2014, 48(9): 62-64.

吴振兴, 邹云屏, 张允, 等. 单相PWM整流器输入电流波形的改善技术[J]. 高电压技术, 2008, 34(3): 603-608.

WU Zhenxing, ZOU Yunping, ZHANG Yun, et al. Supply current waveform improvement technique for single-phase PWM rectifier[J]. High voltage engineering, 2008, 34(3): 603-608.

刘通, 刘文生. 具有低次谐波电流抑制能力的网侧牵引变流器算法研究[J]. 机车电传动, 2018(3): 57-61.

LIU Tong, LIU Wensheng. Research on grid-side traction converter with low-order harmonic current suppression capability[J]. Electric drive for locomotives, 2018(3): 57-61.

汤旻安, 高晓红. 不平衡电网电压条件下光储微电网并网控制[J]. 高电压技术, 2019, 45(6): 1879-1888.

TANG Minan, GAO Xiaohong. Grid-connected control of microgrid with photovoltaic and energy storage systems under unbalanced grid voltage conditions[J]. High voltage engineering, 2019, 45(6): 1879-1888.

崔恒斌, 冯晓云, 张杰, 等. 基于载波脉宽调制技术的牵引整流器谐波特性分析方法[J]. 电工技术学报, 2013, 28(9): 21-31.

CUI Hengbin, FENG Xiaoyun, ZHANG Jie, et al. Harmonic characteristic analysis of carrier based pules-width modulation traction rectifier[J]. Transactions of China electrotechnical society, 2013, 28(9): 21-31.

ZHANG Hailin, YAO Jun, KOU Baoquan, et al. High-precision control for ZVS inverter to reduce nonlinear distortion of semiconductor voltage drop[J]. IEEE transactions on power electronics, 2020, 35(4): 3337-3342.

杨立永, 王立强, 谢晓峰. 基于无差拍控制的三相PWM整流器死区补偿方法[J]. 电力电子技术, 2017, 51(2): 11-14.

YANG Liyong, WANG Liqiang, XIE Xiaofeng. Dead-time compensation method in three-phase PWM rectifier based on deadbeat control[J]. Power electronics, 2017, 51(2): 11-14.

赵鲁, 李耀华, 葛琼璇, 等. 单相PWM整流器死区补偿方法[J]. 电机与控制学报, 2015, 19(6): 6-13.

ZHAO Lu, LI Yaohua, GE Qiongxuan, et al. Dead time compensation method of single-phase PWM rectifier[J]. Electric machines and control, 2015, 19(6): 6-13.

SHEIANOV A, XIAO Xi, SUN Xudong. Adaptive dead-time compensation for high-frequency three-level sparse NPC inverter[J]. IEEE journal of emerging and selected topics in power electronics, 2023, 11(5): 5169-5182.

王顺亮. 电力牵引多电平网侧变流器谐波抑制与调制方法研究[D]. 成都: 西南交通大学, 2016.

WANG Shunliang. Harmonic suppression and modulation method research for multilevel grid-side converter in electric railway traction[D]. Chengdu: Southwest Jiaotong University, 2016.

宋文祥, 张旭. 基于电流矢量的三电平逆变器死区和管压降补偿策略[J]. 电工电能新技术, 2012, 31(2): 47-51.

SONG Wenxiang, ZHANG Xu. Dead time and forward voltage compensation strategy of three level inverter based on the current vector[J]. Advanced technology of electrical engineering and energy, 2012, 31(2): 47-51.

刘博, 贲洪奇, 白银龙, 等. PWM整流器轻载条件下网侧电流谐波分析与抑制[J]. 电工技术学报, 2016, 31(增刊1): 162-168.

LIU Bo, BEN Hongqi, BAI Yinlong, et al. Analysis and suppression of current harmonics in grid side of PWM rectifiers during light load[J]. Transactions of China electrotechnical society, 2016, 31(Suppl 1): 162-168.

刘和平, 路莹超, 王华斌, 等. 电压型逆变器分段死区补偿调制策略[J]. 电机与控制学报, 2018, 22(3): 25-32.

LIU Heping, LU Yingchao, WANG Huabin, et al. Dead-time compensation modulation strategy of subsection integrated in voltage source inverte[J]. Electric machines and control, 2018, 22(3): 25-32.

Views

下载量

CSCD

CNKI被引量

Alert me when the article has been cited

提交

Tools

Publicity Resources

No data

Related Author

No data

Related Institution

No data

⁰